盾构隧道微扰动注浆对土体强度和衬砌横向收敛的影响
作者:
作者单位:

1.同济大学 岩土及地下工程教育部重点实验室,上海 200092;2.同济大学 土木工程学院,上海 200092;3.上海地铁维护保障有限公司,上海 200070

作者简介:

赵 帅(1989—),男,博士生,主要研究方向为隧道结构健康监测与检测运营、隧道结构安全等。 E-mail: zhaos@tongji.edu.cn

通讯作者:

张东明(1987—),男,教授,博士生导师,工学博士,主要研究方向为软土盾构隧道等。 E-mail: 09zhang@tongji.edu.cn

中图分类号:

TU41

基金项目:

国家自然科学基金(51978516,52022070);上海市科学技术委员会科技计划(18DZ1201200)


Influence of Perturbation Grouting of Shield Tunnel on Soil Strength and Transverse Convergence of Tunnel Linings
Author:
Affiliation:

1.Key Laboratory of Geotechnical and Underground Engineering of the Ministry of Education, Tongji University, Shanghai 200092, China;2.College of Civil Engineering, Tongji University, Shanghai 200092, China;3.Shanghai Rail Transit Maintenance Support Co., Ltd., Shanghai 200070, China

Fund Project:

  • 摘要
  • |
  • 图/表
  • |
  • 访问统计
  • |
  • 参考文献
  • |
  • 相似文献
  • |
  • 引证文献
  • |
  • 资源附件
  • |
  • 文章评论
    摘要:

    软土盾构隧道横向变形直接关系到结构安全,常采用微扰动注浆方法控制。为研究隧道微扰动注浆效果,针对一段隧道双侧微扰动注浆加固后的地层,开展了静力触探试验,分析注浆对隧道周围土体的影响规律;对现场获取的土样开展了室内K0固结不排水伸长剪切实验,获得了注浆前后土体伸长剪切强度su和刚度E50的变化量;采用线性模型拟合注浆量和收敛值比值数据,建立了可描述相对注浆量与注浆前后收敛值比值关系的方程式,分析了注浆对收敛值降低的效果。研究结果表明,注浆使锥尖阻力提高了110.8%(注浆中心区)和97.6%(注浆边缘区),注浆加固效果呈现非均匀性;注浆后土体的su比注浆前提高了约112%,E50提高了约132%;注浆使隧道的横向收敛累计值平均降低了约24%。利用得到的结果,可根据浆液用量对隧道横向收敛的恢复进行估算,为后续设计微扰动注浆方案治理软土盾构隧道的横向收敛提供借鉴。

    Abstract:

    The transverse deformation of shield tunnels in soft soils may ultimately threaten the safety of tunnel structure and is often controlled by using the perturbation grouting method. To study the effect of perturbation grouting around a tunnel, cone penetration tests were conducted to analyze the influence of grouting on the soil around two sides of a tunnel and reinforced through grouting. K0 consolidated undrained extensive shearing triaxial tests were performed on standard samples made from the soil obtained from field, and, as a result, the undrained extensive shear strength and the secant modulus were computed. A linear model was used to fit the data of grouting volume and horizontal convergence of the tunnel, and thus, an equation was built to describe the relationship between the normalized convergence value and the relative grouting volume. The effect of grouting on reducing horizontal convergence was analyzed using the built equation. The results show that perturbation grouting improves the ps by 110.8% of the soil at the grouting center and 97.6% of the soil at the edge of the grouting region, and the grouting reinforcement effect is non-uniform. In addition, the su of the soil after grouting is increased by about 112% and the E50 by about 132%. The cumulative horizontal convergence of the tunnel is reduced by about 24% after grouting measures are adopted. Using the obtained results, the recovery extent of the transverse deformation of a tunnel can be estimated according to the amount of grout, which can provide reference for subsequent design of perturbation grouting schemes to treat the transverse deformation of the soft soil shield tunnels.

    参考文献
    相似文献
    引证文献
引用本文

赵帅,张东明,邵华,黄宏伟.盾构隧道微扰动注浆对土体强度和衬砌横向收敛的影响[J].同济大学学报(自然科学版),2022,50(8):1145~1153

复制
分享
文章指标
  • 点击次数:
  • 下载次数:
  • HTML阅读次数:
  • 引用次数:
历史
  • 收稿日期:2021-07-23
  • 最后修改日期:
  • 录用日期:
  • 在线发布日期: 2022-08-24
  • 出版日期: